Anticorrosion Scheme for Concrete Chimney in Flue Gas Desulphurization System
摘 要
采用改性环氧配套衬里的方案制备防腐蚀层。对普通混凝土试样与陶粒砼试样及防腐蚀层在脱硫系统烟道内的现场腐蚀行为进行试验研究。试验6个月后环氧配套衬里层没有鼓泡烧蚀,未观察到明显的变化。采用环氧配套衬里防腐蚀层的混凝土试块,在试验6个月后其内部的钢筋未发现腐蚀现象,表明环氧配套衬里对混凝土中的钢筋起到了较好的保护作用。试验6个月后环氧配套衬里混凝土样的能谱结果均未检测到氯元素,硫元素的含量同未试验的对比测试样相比也未增加,表明环氧配套衬里对混凝土起到了很好的保护作用。工程应用结果表明,改性环氧配套衬里的防腐蚀方案能够对湿法脱硫系统的混凝土烟道起到很好的防腐蚀保护作用。
Abstract
The corrosion behavior of bare common concrete, bare ceramsite concrete and test blocks with modified epoxy liner anticorrosion coating was studied in concrete chimney of flue gas desulphurization systems. Blister of the coating and other obvious changes did not appear on the epoxy liners after 6 months test. No any corrosion indication happened to the rebar in concrete block with epoxy liner anticorrosion coating, indicating a good protection to the rebar in concrete block. After 6 months test, the chlorine element in concrete block with epoxy liners was not found by the analysis result of energy dispersive spectrometer, and the content of sulfur did not increase compared with the untested concrete block. The results showed that the epoxy liner anticorrosion coating could prevent the permeation of harmful corrosives and provide the concrete block with very good protection. The results of engineering application experiment also proved the very good protection of epoxy liner anticorrosion scheme for concrete chimney in flue gas desulphurization systems.
中图分类号 X77
所属栏目 应用技术
基金项目
收稿日期 2013/12/25
修改稿日期
网络出版日期
作者单位点击查看
备注李建三(1973-),副教授,硕士,从事材料腐蚀与安全防护技术工作,
引用该论文: HE Si-li,LI Jian-san,LONG Nai-jian,ZENG Song-feng. Anticorrosion Scheme for Concrete Chimney in Flue Gas Desulphurization System[J]. Corrosion & Protection, 2014, 35(11): 1152
共有人对该论文发表了看法,其中:
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】邓宇强,林卫丽,张祥金,等. 火力发电厂烟气脱硫后烟囱的腐蚀与防护[J]. 腐蚀与防护,2011,32(9):721-724.
【2】何思立,李建三,李咏梅,等. 脱硫系统烟气区混凝土及防护层现场腐蚀试验[J]. 腐蚀与防护,2011,32(7):567-569.
【3】梁磊. 乙烯基酯树脂鳞片材料在火电厂氨法烟气脱硫系统中的应用[J]. 腐蚀与防护,2012,33(2):167-170.
【4】王忠熬,吴恒刚. 泡沫玻璃砖在烟囱防腐中的应用[J]. 电力科技与环保,2012,28(2):45-47.
【5】赵贵生,陈学敏,杨晓峰. OM防腐涂料在单筒钢筋混凝土脱硫烟囱改造中的应用[J]. 武汉大学学报:工学版,2013,46(S1):425-428.
【6】张贻刚,李淑英. 烟气脱硫装置中玻璃鳞片涂层的腐蚀行为[J]. 腐蚀与防护,2010,31(2):161-163.
【7】杨彦. 火力发电厂湿法烟气脱硫系统烟囱腐蚀与防腐研究[D]. 北京:北京交通大学硕士学位论文,2010.
【8】景俊艳,张红日. 湿法脱硫烟囱防腐技术探讨[J]. 山西建筑,2013,39(30):94-95.
【9】解宝安. 火电厂单筒钢筋混凝土烟囱筒壁渗漏腐蚀的修复和改造案例[J]. 特种结构,2013,30(2)26-33.
【2】何思立,李建三,李咏梅,等. 脱硫系统烟气区混凝土及防护层现场腐蚀试验[J]. 腐蚀与防护,2011,32(7):567-569.
【3】梁磊. 乙烯基酯树脂鳞片材料在火电厂氨法烟气脱硫系统中的应用[J]. 腐蚀与防护,2012,33(2):167-170.
【4】王忠熬,吴恒刚. 泡沫玻璃砖在烟囱防腐中的应用[J]. 电力科技与环保,2012,28(2):45-47.
【5】赵贵生,陈学敏,杨晓峰. OM防腐涂料在单筒钢筋混凝土脱硫烟囱改造中的应用[J]. 武汉大学学报:工学版,2013,46(S1):425-428.
【6】张贻刚,李淑英. 烟气脱硫装置中玻璃鳞片涂层的腐蚀行为[J]. 腐蚀与防护,2010,31(2):161-163.
【7】杨彦. 火力发电厂湿法烟气脱硫系统烟囱腐蚀与防腐研究[D]. 北京:北京交通大学硕士学位论文,2010.
【8】景俊艳,张红日. 湿法脱硫烟囱防腐技术探讨[J]. 山西建筑,2013,39(30):94-95.
【9】解宝安. 火电厂单筒钢筋混凝土烟囱筒壁渗漏腐蚀的修复和改造案例[J]. 特种结构,2013,30(2)26-33.
相关信息