HPLC Determination of 2-Mercatobenzothiozole in Rubber Products
摘 要
采用高效液相色谱法测定橡胶制品中2-巯基苯并噻唑的含量。样品经丙酮超声提取两次。采用C18反相色谱柱为分离柱,以甲醇-0.01 mol·L-1磷酸二氢钠(80+20)溶液为流动相,在检测波长320 nm处进行测定。2-巯基苯并噻唑的质量浓度在0.10~10.0 mg·L-1范围内与其峰面积呈线性关系,方法的检出限(3S/N)为0.54 mg·kg-1。在0.10,2.0,10.0 mg·L-1等3个浓度水平进行加标回收试验,回收率在85.3%~95.4%之间,测定值的相对标准偏差(n=6)在3.1%~5.6%之间。
Abstract
HPLC was applied to the determination of 2-mercatobenzothiozole(MBT) in rubber products. The sample was extracted ultrasonically with acetone twice. C18 reverse-phase chromatographic column was used as stationary phase, and a mixture of methanol-0.01 mol·L-1 NaH2PO4 solution (80+20) was used as mobile phase. The UV detector at 320 nm was used. Linear relationship between peak area and mass concentration of 2-MBT was in the range of 0.1-10.0 mg·L-1 with detection limit (3S/N) of 0.54 mg·kg-1. Recovery obtained by standard addition method at concentrations of 0.10, 2.0, 10.0 mg·L-1, and RSD′s (n=6) were in the ranges of 85.3%-95.4% and 3.1%-5.6%, respectively.
中图分类号 O652.63
所属栏目 工作简报
基金项目 国家质检总局科研项目(2012IK106)资助
收稿日期 2014/3/12
修改稿日期
网络出版日期
作者单位点击查看
备注毛树禄(1978-),男,福建福安人,高级工程师,主要从事轻工产品检测工作。
引用该论文: MAO Shu-lu,Lv Pei-qi,ZHANG Yuan-jin,LI Xiao-ya,CHEN Jing-hua. HPLC Determination of 2-Mercatobenzothiozole in Rubber Products[J]. Physical Testing and Chemical Analysis part B:Chemical Analysis, 2014, 50(10): 1242~1244
毛树禄,吕培其,张元金,李小娅,陈敬华. 高效液相色谱法测定橡胶制品中2-巯基苯并噻唑[J]. 理化检验-化学分册, 2014, 50(10): 1242~1244
共有人对该论文发表了看法,其中:
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】李斌,陈元春.2-巯基苯并噻唑[J].精细与专用化学品, 2005,13(18): 10-11.
【2】ASTM D7558-2009Standard test method for colorimetric/spectrophotometric procedure to quantify extractable chemical dialkyldithiocarbamate, thiuram, and mercaptobenzothiazole accelerators in natural rubber latex and nitrile gloves[S].
【2】ASTM D7558-2009Standard test method for colorimetric/spectrophotometric procedure to quantify extractable chemical dialkyldithiocarbamate, thiuram, and mercaptobenzothiazole accelerators in natural rubber latex and nitrile gloves[S].
相关信息