HG-AFS Determination of Mercury in Rubber and Its Products with Microwave Assisted Sample Digestion
摘 要
称取经冷冻粉碎的橡胶样品0.2 g,用硝酸6 mL和过氧化氢2 mL在密闭的聚四氟乙烯(PTFE)消解罐中进行微波消解,所得溶液定容至50 mL。分取此溶液5.00 mL,加盐酸(5+95)溶液至10 mL,用氢化物发生-原子荧光光谱法测定此溶液中的汞含量。经试验选定分析条件:① 用0.5 g·L-1硼氢化钾溶液(溶于2 g·L-1氢氧化钠溶液中)作还原剂;② 以盐酸(5+95)溶液作载流;③ 光电倍增管负高压为260 V;④ 灯电流为15 mA;⑤ 原子化器高度为10 mm;⑥ 载气和屏蔽气流量依次为300,800 mL·min-1。方法的检出限(3s/k)为3 μg·L-1。用标准加入法做回收试验,测得平均回收率为95.7%,测定值的相对标准偏差(n=11)为4.3%。选取含汞高及低量的样品各1个,分别由10家实验室对所提出的方法做验证,结果较好。
Abstract
The rubber sample was smashed with a frozen grinder, and a portion of 0.2 g of sample was taken and digested with 6 mL of HNO3 and 2 mL of H2O2 in a closed PTFE digester. The solution obtained was made up to 50 mL, and an aliquot of 5.00 mL after diluting to 10 mL with HCl(5+95) was used for HG-AFS determination of its Hg-content. Analytical conditions were optimized as follows: ① 0.5 g·L-1 solution of KBH4 dissolved in 2 g·L-1 NaOH solution was used as reductant; ② HCl(5+95) solution was used as carrier; ③ negative high voltage of photomultiplier: 260 V; ④ lamp current: 15 mA; ⑤ height of atomizer: 10 mm; ⑥ flow-rate of carrier gas and shielding gas: 300, 800 mL·min-1 respectively. Detection limit (3s/k) found was 3 μg·L-1. Value of average recovery found by standard addition method was 95.7%, with RSD (n=11) of 4.3%. Accuracy and precision of this method were further verified by an inter laboratory program among 10 laboratories, and satisfactory results were obtained.
中图分类号 O657.31
所属栏目 工作简报
基金项目 国家质量监督检验检疫总局科研制标项目(2009B661)
收稿日期 2013/11/10
修改稿日期
网络出版日期
作者单位点击查看
联系人作者刘崇华(Liuch@iqtc.cn)
备注刘崇华(1974-)男,江西吉安人,高级工程师,主要从事玩具等消费产品化学检验。
引用该论文: LIU Chong-hua,ZHOU Xiao-li,SHEN Xiao-luan,HUANG Gang. HG-AFS Determination of Mercury in Rubber and Its Products with Microwave Assisted Sample Digestion[J]. Physical Testing and Chemical Analysis part B:Chemical Analysis, 2014, 50(12): 1567~1570
刘崇华,周小丽,沈晓銮,黄刚. 微波消解样品-氢化物发生-原子荧光光谱法测定橡胶及其制品中微量汞[J]. 理化检验-化学分册, 2014, 50(12): 1567~1570
共有人对该论文发表了看法,其中:
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】万双秀,王俊东.汞对人体神经的毒性及其危害[J].微量元素与健康研究, 2005,22(2):67-69.
【2】Directive 2002/95/EC of the European Parliament and of the Coucil of 27 January 2003 on the restriction of the use of certain hazardous substances in electrical and electronic equipment[S].
【3】GB/T 26572-2011电子电气产品中限用物质的限量要求[S].
【4】Directive 2000/53/EC of The European Parliament and of the Council of 18 September 2000 on the end of life vehicles[S].
【5】卢业有,杨芬.原子荧光光谱法测定土壤中汞[J].理化检验-化学分册, 2011,47(1):106-116.
【6】王豪,邬蓓蕾,陈平,等.微波消解样品-原子荧光光谱法测定原油中铅、砷和汞含量[J].理化检验-化学分册, 2012,48(9):1027-1029.
【7】刘崇华,沈晓銮,周小丽,等.微波消解-原子吸收光谱法测定橡胶及其制品中镉[J].分析试验室, 2009,28(8):86-89.
【2】Directive 2002/95/EC of the European Parliament and of the Coucil of 27 January 2003 on the restriction of the use of certain hazardous substances in electrical and electronic equipment[S].
【3】GB/T 26572-2011电子电气产品中限用物质的限量要求[S].
【4】Directive 2000/53/EC of The European Parliament and of the Council of 18 September 2000 on the end of life vehicles[S].
【5】卢业有,杨芬.原子荧光光谱法测定土壤中汞[J].理化检验-化学分册, 2011,47(1):106-116.
【6】王豪,邬蓓蕾,陈平,等.微波消解样品-原子荧光光谱法测定原油中铅、砷和汞含量[J].理化检验-化学分册, 2012,48(9):1027-1029.
【7】刘崇华,沈晓銮,周小丽,等.微波消解-原子吸收光谱法测定橡胶及其制品中镉[J].分析试验室, 2009,28(8):86-89.
相关信息