气体分压比对20#钢在H2S/CO2环境中腐蚀的影响
Influence of Gas Partial Pressure Ratio on Corrosion of 20# Pipeline Steel in H2S/CO2 Environment
摘 要
采用常温高压条件下的挂片试验，结合SEM和EDS等技术，研究了20#钢在H2S/CO2环境中不同气体分压比(pCO2/pH2S)条件下的腐蚀行为。结果表明，在试验环境中，20#钢的腐蚀以均匀腐蚀为主，伴有轻微的局部腐蚀; 在低气体分压比情况下，腐蚀呈现先增大后减小再增大的规律; 依据腐蚀规律，可将低分压比变化范围分为两个区域，在两个腐蚀区域内，腐蚀产物的元素百分含量差别不大，腐蚀产物以FeS和FeCO3为主。
H2S/CO2腐蚀
气体分压比
腐蚀速率
20# pipeline steel
H2S/CO2 corrosion
gas partial pressure ratio
corrosion rate
Abstract
The corrosion behavior of 20# pipeline steel in H2S/CO2 environments at normal temperature as well as high pressure was studied by weight loss measurement, and the surface analysis of the steel was performed by SEM and EDS. The results show that the general corrosion along with slight localized corrosion occurred in this system. At the low gas partial pressure ratio, the corrosion rate increased first, then decreased and increased again at last. According to the corrosion law, the range of low gas partial pressure can be divided into two areas. In these two corrosion areas, the percentage variations of corrosion product elements were similar, corrosion produts were mainly FeS and FeCO3.
中图分类号 TG172.3
所属栏目 试验研究
基金项目
收稿日期 2012/9/1
修改稿日期
网络出版日期
作者单位点击查看
备注袁宗明,教授,博士生导师,
引用该论文: REN Jian-xun,YUAN Zong-ming,HE San,QU Yang,LI Jian-feng. Influence of Gas Partial Pressure Ratio on Corrosion of 20# Pipeline Steel in H2S/CO2 Environment[J]. Corrosion & Protection, 2013, 34(8): 706
共有人对该论文发表了看法，其中：
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】白真权,李鹤林,刘道新,等. 模拟油田H2S/CO2环境中N80钢的腐蚀及影响因素研究[J]. 材料保护,2003,36(4):32-34.
【2】张雷,丁睿明,杨建炜,等. 高含H2S/CO2介质中X60钢腐蚀产物膜分析[J]. 北京科技大学学报,2009,31(5):563-567.
【3】周计明. 油管钢在含CO2/H2S高温高压水介质中的腐蚀行为及防护技术的作用[D]. 西安:西北工业大学硕士学位论文,2002.
【4】Srinivasan S,Kane R D. Experimental simulation of multiphase CO2/H2S systems[J]. Corrosion,1999(14):2651-2655.
【5】黄雪松. H2S和CO2分压及Cl-浓度对L360QCS钢腐蚀行为的影响[J]. 腐蚀与防护,2012,33(6):475-462.
【6】闫伟,邓金根,董星亮,等. 油管钢在CO2/H2S环境中的腐蚀产物及腐蚀行为[J]. 腐蚀与防护,2011,32(3):193-196.
【2】张雷,丁睿明,杨建炜,等. 高含H2S/CO2介质中X60钢腐蚀产物膜分析[J]. 北京科技大学学报,2009,31(5):563-567.
【3】周计明. 油管钢在含CO2/H2S高温高压水介质中的腐蚀行为及防护技术的作用[D]. 西安:西北工业大学硕士学位论文,2002.
【4】Srinivasan S,Kane R D. Experimental simulation of multiphase CO2/H2S systems[J]. Corrosion,1999(14):2651-2655.
【5】黄雪松. H2S和CO2分压及Cl-浓度对L360QCS钢腐蚀行为的影响[J]. 腐蚀与防护,2012,33(6):475-462.
【6】闫伟,邓金根,董星亮,等. 油管钢在CO2/H2S环境中的腐蚀产物及腐蚀行为[J]. 腐蚀与防护,2011,32(3):193-196.
相关信息
