Electrochemical Corrosion Behavior of Ti70 Alloy in HF-HNO3 System
摘 要
采用开路电位测量、电化学阻抗谱及极化曲线测量等方法研究了钛合金Ti70(Ti-2.5Al-2Zr-1Fe)在HF-HNO3体系中的电化学腐蚀行为。结果表明,随着氢氟酸浓度的增加,Ti70合金的腐蚀速率增大; 氢氟酸浓度一定时,随着硝酸与氢氟酸体积比的增大,Ti70合金的开路电位降低,容抗弧增大; 极化曲线由活化向自钝化特征转化。Ti70合金在浸泡初期,其电化学阻抗谱出现低频感抗弧; 随着浸泡时间的延长,溶液中的离子在合金表面进行沉积,形成一层致密的钝化膜,从而出现中高频段的双容抗弧。
Abstract
The electrochemical corrosion behavior of Ti70 alloy in HF-HNO3 system was investigated by measurements of open-circuit potentials, EIS and polarization curves. The results show that the corrosion rate of Ti70 increased with the HF concentration increasing. When the HF concentration was constant, the open-circuit potential decreased and the capacitance arc increased with increasing the volume ratio of HNO3 to HF. The obvious active-passive transition could be seen in the polarization curves. At the early stage of corrosion, an inductive arc at low frequency appeared. With extending the immersion time, a compact passivated film formed on the alloy surface. Two capacitance arcs appeared at high and medium frequencies respectively.
中图分类号 TG174.3
所属栏目 试验研究
基金项目
收稿日期 2012/12/17
修改稿日期
网络出版日期
作者单位点击查看
备注王悔改,讲师,硕士,
引用该论文: WANG Hui-gai,SONG Yan-pei. Electrochemical Corrosion Behavior of Ti70 Alloy in HF-HNO3 System[J]. Corrosion & Protection, 2013, 34(10): 914
共有人对该论文发表了看法,其中:
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】孟祥军,时锦. 漫谈钛合金在舰船上的应用[J]. 钛工业进展,2003,20(4):23-26.
【2】孙建科,孟祥军,陈春和,等. 我国船用钛合金研究、应用及发展[J]. 金属学报,2002,38(增刊1):33-36.
【3】赵永庆. 国内外钛合金研究的发展现状及趋势[J]. 中国材料进展,2010,29(5):1-7.
【4】余存烨. 耐蚀钛合金的发展[J]. 钛工业进展,2003,20(1):12-19.
【5】杨东,郭金明. 钛合金的腐蚀机理及耐蚀钛合金的发展现状[J]. 钛工业进展,2011,28(2):4-7.
【6】余存烨. 锆与钛耐蚀性比较及应用互补性[J]. 腐蚀与防护,2007,28(5):223-226.
【7】Utmo W B,Donne S W. Electrochemical behavior of titanium in H2SO4-MnSO4 electrolytes[J]. Electrochinica Acta,2006,51(1):3338-3345.
【8】林翠,刘枫,赵晴,等. 氢氟酸-硝酸体系中TC4钛合金的腐蚀行为[J]. 失效分析与预防,2008,3(2):11-15.
【2】孙建科,孟祥军,陈春和,等. 我国船用钛合金研究、应用及发展[J]. 金属学报,2002,38(增刊1):33-36.
【3】赵永庆. 国内外钛合金研究的发展现状及趋势[J]. 中国材料进展,2010,29(5):1-7.
【4】余存烨. 耐蚀钛合金的发展[J]. 钛工业进展,2003,20(1):12-19.
【5】杨东,郭金明. 钛合金的腐蚀机理及耐蚀钛合金的发展现状[J]. 钛工业进展,2011,28(2):4-7.
【6】余存烨. 锆与钛耐蚀性比较及应用互补性[J]. 腐蚀与防护,2007,28(5):223-226.
【7】Utmo W B,Donne S W. Electrochemical behavior of titanium in H2SO4-MnSO4 electrolytes[J]. Electrochinica Acta,2006,51(1):3338-3345.
【8】林翠,刘枫,赵晴,等. 氢氟酸-硝酸体系中TC4钛合金的腐蚀行为[J]. 失效分析与预防,2008,3(2):11-15.
相关信息