Conductive Property and Corrosion Resistance of Graphite Epoxide Resin Anti-static Paints in High-sulfur Crude Oil
摘 要
针对高硫原油腐蚀严重的实际,选用环氧树脂为成膜物,填充石墨制备抗静电耐蚀涂料.采用静态浸渍法研究了石墨含量和硫浓度对涂料导电性、耐蚀性的影响.结果表明,室温下,在环氧树脂中添加35%的石墨制成的涂料可达到抗静电和耐蚀的要求;当温度为50~70 ℃时,石墨加入量为45%时耐蚀性较好.原油中硫含量变化对涂料耐蚀性影响较小.
Abstract
An anti-static and corrosion-resistant paint with epoxide resin as film forming matter and graphite powder as carrier was prepared to solve the corrosion problem of high-sulfur crude oil.The effects of graphite content and sulfur concentration on the conductive property and corrosion resistance were studied by static immersion method.The results showed that the corrosion resistance and the conductivity could meet the requirements when graphite content was 35% at room-temperature.When temperature was 50~70 ℃,corrosion resistance was fairly good when graphite content was 45%.The effect of sulfur concentration on the corrosion resistance of anti-static paints was small.
中图分类号 TG174.46
所属栏目 试验研究
基金项目
收稿日期 2007/3/22
修改稿日期 2007/4/9
网络出版日期
作者单位点击查看
引用该论文: XUE Jing,LEI Jun-bo,FENG La-jun. Conductive Property and Corrosion Resistance of Graphite Epoxide Resin Anti-static Paints in High-sulfur Crude Oil[J]. Corrosion & Protection, 2008, 29(4): 195~198
共有人对该论文发表了看法,其中:
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】毛力之,李挺芳.炼制高硫原油的腐蚀与防护[J].石油化工腐蚀与防护,1995(2):1-8.
【2】李公权,傅大海,郭铭,等.油罐抗静电耐油防腐涂料的选材[J].涂料工业,2000(2):18-19.
【3】张勇.加工高硫高酸原油设备的腐蚀分析与防护措施[J].清洗世界,2005(7):21-26.
【4】张振宁,张公正,王正刚.炭系混合填料在导电涂料中应用的研究[J].涂料工业,1997(5):9-11.
【5】林莉萍.抗静电涂料的研究[J].新技术新工艺·材料与表面处理,2001(7):47-48.
【2】李公权,傅大海,郭铭,等.油罐抗静电耐油防腐涂料的选材[J].涂料工业,2000(2):18-19.
【3】张勇.加工高硫高酸原油设备的腐蚀分析与防护措施[J].清洗世界,2005(7):21-26.
【4】张振宁,张公正,王正刚.炭系混合填料在导电涂料中应用的研究[J].涂料工业,1997(5):9-11.
【5】林莉萍.抗静电涂料的研究[J].新技术新工艺·材料与表面处理,2001(7):47-48.
相关信息