Effects of Bath Temperature on Electroless Ni-P Plating of AZ31 Magnesium Alloy
摘 要
分析了AZ31镁合金表面化学镀镍磷合金工艺中,温度对镀层硬度、沉积速率、耐腐蚀性、微结构及形貌等特性的影响.结果表明,在镀液pH值为6.5,化学镀时间为45 min时,施镀的最佳温度为85~90 ℃,所得到的镁合金表面镀层光亮,胞状组织均匀致密,与基体结合牢固,耐蚀性明显提高,并具有较高的硬度.
Abstract
The effects of temperature on micro-hardness,depositing velocity,corrosion resistance,microstructure and morphology of the electroless plated Ni-P coatings on AZ31 magnesium were analyzed.The results revealed that the depositing temperature was an important parameter which influenced the coating performance greatly.The coatings with properties of bright surface,uniform and dense structure,strong adhesion with substrate,good corrosion resistance and so on were obtained when the depositing temperature was 85~90 ℃.
中图分类号 TG146.2 TG174.44
所属栏目 试验研究
基金项目 上海市重点学科建设项目(B503)资助
收稿日期 2009/7/19
修改稿日期 2009/8/19
网络出版日期
作者单位点击查看
备注尚淑珍,讲师.
引用该论文: SHANG Shu-zhen,LU Gui-min,ZHAO Zu-xin,WAN Yi-jun. Effects of Bath Temperature on Electroless Ni-P Plating of AZ31 Magnesium Alloy[J]. Corrosion & Protection, 2010, 31(2): 125~127
共有人对该论文发表了看法,其中:
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】Sharma A K,Rani R U,Giri K.Magnesium alloys surface treatment[J].Metal Finish,1997,93(3):43-48.
【2】刘汝涛,高灿柱,杨景和,等.影响化学镀镍稳定性因素的研究[J].表面技术,2001,30(1):10-12.
【3】Gray J E,Luan B.Applied surface science of Mg alloys[J].J.Alloys Compd,2002,336(8):88-92.
【4】Singh Raman R K,Birbilis N,Efthimiadis J,et al.Take advantage of electroless coating[J].Sci Tech,2004,39(4):346-349.
【5】陈志勇,刘沙沙,李忠厚.镁合金在中性镀液中化学镀Ni-P合金研究[J].材料与表面处理技术,2007(9):72-74.
【6】贺海丽,郑兴周,王桂香,等.镁合金化学镀镍工艺研究进展[J].电镀与环保,2007,27(3):1-3.
【7】郭长春,成旦红,李科军,等.镁合金直接化学镀Ni-P合金工艺[J].电镀与精饰,2007,29(4):23-26.
【2】刘汝涛,高灿柱,杨景和,等.影响化学镀镍稳定性因素的研究[J].表面技术,2001,30(1):10-12.
【3】Gray J E,Luan B.Applied surface science of Mg alloys[J].J.Alloys Compd,2002,336(8):88-92.
【4】Singh Raman R K,Birbilis N,Efthimiadis J,et al.Take advantage of electroless coating[J].Sci Tech,2004,39(4):346-349.
【5】陈志勇,刘沙沙,李忠厚.镁合金在中性镀液中化学镀Ni-P合金研究[J].材料与表面处理技术,2007(9):72-74.
【6】贺海丽,郑兴周,王桂香,等.镁合金化学镀镍工艺研究进展[J].电镀与环保,2007,27(3):1-3.
【7】郭长春,成旦红,李科军,等.镁合金直接化学镀Ni-P合金工艺[J].电镀与精饰,2007,29(4):23-26.
相关信息