Eddy Current Signal on Anti-vibration Bars of Steam Generator Tubes
摘 要
蒸汽发生器U型传热管在弯管段设有防振条,用于支撑管束并避免不可接受的流致振动或微振动引发的磨损。介绍了55/19B型蒸汽发生器传热管防振条易出现的偏移、错位、扭转等问题,并针对这些问题,利用涡流检测方法对相应的防振条信号进行分析,并得出各涡流信号的特点。结果表明,通过涡流检测方法,可检测出蒸汽发生器传热管防振条的偏移、错位、扭转。
Abstract
U type of steam generator heat transfer tube in a bend pipe is provided with an anti-vibration strip and tube bundle support for avoiding unacceptable flow induced vibration or micro vibration caused by wear and tear. The 55/19B type steam generator heat transfer tube of anti-vibration bars appears to induce offset and dislocation torsion problem. In order to solve these problems, eddy current testing method was used to analyze the corresponding anti-vibration signal and the characteristics of the eddy current signal were obtained. Results show that, the eddy current testing method can detect the offset of steam generator tube of anti-vibration bars, the dislocation and the torsion.
中图分类号 TG115.28 DOI 10.11973/wsjc201604004
所属栏目 试验研究
基金项目
收稿日期 2015/9/17
修改稿日期
网络出版日期
作者单位点击查看
备注孔玉莹(1984-),女,工程师,主要从事核电站涡流检测与研发工作。
引用该论文: KONG Yu-ying,LU Ji,MA Qiang. Eddy Current Signal on Anti-vibration Bars of Steam Generator Tubes[J]. Nondestructive Testing, 2016, 38(4): 15~17
孔玉莹,陆吉,马强. 蒸汽发生器传热管防振条的涡流信号[J]. 无损检测, 2016, 38(4): 15~17
共有人对该论文发表了看法,其中:
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】丁训慎.蒸汽发生器传热管的微振磨损及其防护[J].核安全,2006(3):27-32.
【2】刘敏珊,王素珍,董其伍.防振条对蒸汽发生器U形管动态特性影响研究[J].郑州大学学报,2008,29(2):48-51.
【3】李跃忠,韩良弼,王柏松.蒸汽发生器管束的固有振动分析[J].原子能科学技术,2008,42(增刊):458-462.
【4】《国防科技工业无损检测人员资格鉴定与认证培训教材》编审委员会编.涡流检测[M].北京:机械工业出版社,2004:23-25.
【2】刘敏珊,王素珍,董其伍.防振条对蒸汽发生器U形管动态特性影响研究[J].郑州大学学报,2008,29(2):48-51.
【3】李跃忠,韩良弼,王柏松.蒸汽发生器管束的固有振动分析[J].原子能科学技术,2008,42(增刊):458-462.
【4】《国防科技工业无损检测人员资格鉴定与认证培训教材》编审委员会编.涡流检测[M].北京:机械工业出版社,2004:23-25.
相关信息