Mutual Interference between Cathodic Protection Systems of Adjacent Pipelines
摘 要
以西部某相邻管道为实例,对相邻管道的管地电位、地电位梯度和交流干扰电位进行现场检测,并通过ANSYS软件进行数值模拟,对阳极地床的位置和埋设方式做了分析,最后通过埋设临时地床对模拟结果进行了试验验证。结果表明:管道上杂散电流产生的原因为相邻管线阴极保护系统之间的相互干扰;合理设置阳极地床位置可基本消除阴极保护系统相互间的干扰。
Abstract
Taking adjacent pipelines in Northwest of China for example, the cathodic protection potential, ground potential gradient, and AC interference potential of the adjacent pipelines were tested on the spot. And the position and setting mode of the anode bed were analyzed through numerical simulation using software ANSYS. At last, the simulation results were verified by experiment of temporary buried anode bed. The results indicate that the stray current was caused by mutual interference between different cathodic protection systems. The mutual interference could be eliminated almost by setting anode bed in reasonable location.
中图分类号 TG174.41 DOI 10.11973/fsyfh-201704013
所属栏目 应用技术
基金项目
收稿日期 2015/11/17
修改稿日期
网络出版日期
作者单位点击查看
引用该论文: JIN Guang-bin. Mutual Interference between Cathodic Protection Systems of Adjacent Pipelines[J]. Corrosion & Protection, 2017, 38(4): 306
共有人对该论文发表了看法,其中:
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】鲍元飞,李自力,许甜,等. 交流杂散电流对管道交流干扰电压的影响规律[J]. 腐蚀与防护,2015,36(3):221-225.
【2】陈航的. 长输油气管道工艺站场的区域性阴极保护[J]. 腐蚀与防护,2008,29(8):485-487.
【3】吴进超. 新疆库车末站阴极保护系统优化研究[J]. 重庆科技学院院报,2010,12(5):101-103.
【4】熊金根,李岚鑫,孙冰冰. 工艺管网区域阴极保护系统干扰问题的检测及处理[J]. 石油工程建设,2013,39(5):46-49.
【5】董亮,杜艳霞,路民旭,等. 油气输送站场内外阴极保护系统间干扰数值模拟[J]. 石油学报,2013,34(2):393-400.
【2】陈航的. 长输油气管道工艺站场的区域性阴极保护[J]. 腐蚀与防护,2008,29(8):485-487.
【3】吴进超. 新疆库车末站阴极保护系统优化研究[J]. 重庆科技学院院报,2010,12(5):101-103.
【4】熊金根,李岚鑫,孙冰冰. 工艺管网区域阴极保护系统干扰问题的检测及处理[J]. 石油工程建设,2013,39(5):46-49.
【5】董亮,杜艳霞,路民旭,等. 油气输送站场内外阴极保护系统间干扰数值模拟[J]. 石油学报,2013,34(2):393-400.
相关信息