中/低铬铁素体不锈钢在消声器冷凝液中的腐蚀行为
Corrosion Behavior of Medium/Low Chromium Ferritic Stainless Steels in Condensate of Muffler
摘 要
采用氧化-浸泡-蒸发循环试验方法模拟汽车消声器内部环境，对比研究了409M、425NT、439M三种中/低铬铁素体不锈钢在汽车消声器冷凝液中的腐蚀行为，讨论了合金元素铬的含量对不锈钢耐腐蚀性能的影响。结果表明：三种不锈钢经50次循环试验后均呈现点腐蚀特征，表面的氧化/腐蚀产物主要是（Fe，Cr）2O3；随着铬含量的升高，铁素体不锈钢的腐蚀电位上升，腐蚀阻力增加，腐蚀坑数量减少且深度下降，腐蚀质量损失降低，耐冷凝液腐蚀性能得到明显提高。
汽车消声器
氧化
腐蚀
冷凝液
stainless steel
automotive muffler
oxidation
corrosion
condensate
Abstract
An oxidation-immersion-evaporation cyclic method was used to simulate the internal service environment of automotive muffler. The corrosion behavior of three medium/low chromium ferritic stainless steels (i.e., 409M, 425NT and 439M) was investigated comparatively in the condensate of automotive muffler to elucidate the effect of chromium content on their corrosion resistance. Experimental results revealed that the three stainless steels showed pitting corrosion after fifty cycles of tests and the main oxidation/corrosion products on steel surfaces were (Fe,Cr)2O3. With the increase of chromium content in the stainless steels, the specimens gradually showed higher corrosion potential and corrosion resistance, less pit number and depth values, and lower weight loss. These indicated that the increase of chromium content enhanced noticeably the corrosion resistance of ferritic stainless steel.
中图分类号 TG172 DOI 10.11973/fsyfh-201802001
所属栏目 试验研究
基金项目 国家自然科学基金重点项目（51134010）
收稿日期 2016/5/6
修改稿日期
网络出版日期
作者单位点击查看
引用该论文: ZHANG Guoli,LIU Xing,CHEN Congcong,LI Moucheng. Corrosion Behavior of Medium/Low Chromium Ferritic Stainless Steels in Condensate of Muffler[J]. Corrosion & Protection, 2018, 39(2): 85
共有人对该论文发表了看法，其中：
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】SATO E,TANOUE T. Present and future trends of materials for automotive exhaust system[J]. Nippon Steel Technical Report,1995(64):13-19.
【2】王堂伟,赵玉才,马建军,等. 汽车排气系统用铁素体不锈钢的服役性能[J]. 上海金属,2013,35(4):20-23.
【3】BI H Y,WU Y,LI X. Application and failure evaluation of ferritic stainless steels for automotive exhaust systems[J]. Baosteel Technical Research,2010,4(1):10-14.
【4】CHAO C,SHANG C J,XIN S,et al. Condensate corrosion behavior of new style ferritic stainless steels used in automotive exhaust system[J]. Kang Tieh/iron & Steel,2009,44(10):78-81.
【5】李骏. 中国轻型汽车国Ⅳ国Ⅴ排放法规对比分析[J]. 交通节能与环保,2014(6):49-52.
【6】李振. 汽车排气系统用铁素体不锈钢力学性能和耐腐蚀性能研究[D]. 沈阳:东北大学,2010.
【7】LI M C,ZHANG H,HUANG R F,et al. Effect of SO2 on oxidation of type 409 stainless steel and its implication on condensate corrosion in automotive muffiers[J]. Corrosion Science,2014,80:96-103.
【8】曹楚南. 电化学阻抗谱导论[M]. 北京:科学出版社,2002:76-84.
【9】王芸,汤滢,谢长生,等. 电化学阻抗谱在材料研究中的应用[J]. 材料导报,2011,25(13):5-9.
【2】王堂伟,赵玉才,马建军,等. 汽车排气系统用铁素体不锈钢的服役性能[J]. 上海金属,2013,35(4):20-23.
【3】BI H Y,WU Y,LI X. Application and failure evaluation of ferritic stainless steels for automotive exhaust systems[J]. Baosteel Technical Research,2010,4(1):10-14.
【4】CHAO C,SHANG C J,XIN S,et al. Condensate corrosion behavior of new style ferritic stainless steels used in automotive exhaust system[J]. Kang Tieh/iron & Steel,2009,44(10):78-81.
【5】李骏. 中国轻型汽车国Ⅳ国Ⅴ排放法规对比分析[J]. 交通节能与环保,2014(6):49-52.
【6】李振. 汽车排气系统用铁素体不锈钢力学性能和耐腐蚀性能研究[D]. 沈阳:东北大学,2010.
【7】LI M C,ZHANG H,HUANG R F,et al. Effect of SO2 on oxidation of type 409 stainless steel and its implication on condensate corrosion in automotive muffiers[J]. Corrosion Science,2014,80:96-103.
【8】曹楚南. 电化学阻抗谱导论[M]. 北京:科学出版社,2002:76-84.
【9】王芸,汤滢,谢长生,等. 电化学阻抗谱在材料研究中的应用[J]. 材料导报,2011,25(13):5-9.
相关信息
