Effect of Ageing on Damping Capacities of Ni53Ga27Fe15Co5 Ferromagnetic Shape Memory Alloy
摘 要
采用低频扭摆仪研究了时效对Ni53Ga27Fe15Co5铁磁形状记忆合金阻尼性能的影响.结果表明:时效前后,当应变振幅小于4.0×10-5时,该合金的阻尼性能都依赖于频率,当应变振幅大于4.0×10-5时都取决于应变振幅;经700 ℃时效4 h后该合金的马氏体相变温度降低,逆相变温度升高,相变潜热减小,其阻尼性能约为铸态时的两倍,最大阻尼值达0.139.
Abstract
The effect of ageing on damping capacities of the Ni53Ga27Fe15Co5 ferromagnetic shape memory alloy (FSMA) was investigated by using low frequency torsion pendulum.The results show that when the strain amplitude was less than 4.0×10-5,the damping capacities of the Ni53Ga27Fe15Co5 alloy were determined by frequency,when the strain amplitude was more than 4.0×10-5 those were controlled by strain amplitude before and after ageing.Martensitic transformation temperature decreased,the converse transformation temperature increased and latent heat of phase transition was reduced of the Ni53Ga27Fe15Co5 alloy after ageing at 700 ℃ for 4 h,the damping capacities of the ageing alloy were twice larger than those of the as-cast alloy.The maximum damping capacities reached 0.139.
中图分类号 TG113 TG135.7 TG146.15
所属栏目 试验研究
基金项目
收稿日期 2009/5/19
修改稿日期 2010/2/20
网络出版日期
作者单位点击查看
备注夏明六(1982-),男,安徽巢湖人,硕士研究生.
引用该论文: XIA Ming-liu,MA Li-qun,CHENG Jiang-hui,DING Yi. Effect of Ageing on Damping Capacities of Ni53Ga27Fe15Co5 Ferromagnetic Shape Memory Alloy[J]. Materials for mechancial engineering, 2010, 34(6): 43~46
夏明六,马立群,程江辉,丁毅. 时效对Ni53Ga27Fe15Co5铁磁形状记忆合金阻尼性能的影响夏明六,马立群,程江辉,丁 毅[J]. 机械工程材料, 2010, 34(6): 43~46
共有人对该论文发表了看法,其中:
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】WUTTIG M,LI J,CRACIUNESCU C.A new ferromagnetic shape memory alloy system[J].Scripta Materialia,2001,44:2393-2397.
【2】DEARING N,JENNER A G.Magnetic and magnetoelastic properties of melt-spun Ni-Mn-Ga[J].IEEE Trans Magn,2006,42:78-80.
【3】CHERNENKO V A,PONS J,CESARI E,et al.Transformation behaviour and martensite stabilization in the ferromagnetic Co-Ni-Ga Heusler alloy[J].Scripta Materialia,2004,50:225-229.
【4】FUJITA A,FUKAMICHI K,GEJIMA F,et al.Magnetic properties and large magnetic-field-induced strains in off-stoichiometric Ni-Mn-Al Heusler alloys[J].Applied Physics Letters,2000,77:3054-3056.
【5】OIKAWA K,OTA T,SUTOU Y,et al.Magnetic and martensitic phase transformations in a Ni54Ga27Fe19 alloy[J].Materials Transactions,2002,43:2360-2362.
【6】夏明六,马立群,阮爱杰,等.铁磁性形状记忆合金Ni50Ga27Fe17Co6的阻尼性能[J].机械工程材料,2009,33(3):50-52.
【7】徐祖耀.相变内耗与伪滞弹性[J].金属学报,2003,39(11):1121-1126.
【8】冯端,王业宁,丘第荣.金属物理[M].北京:科学出版社,1975:603-608.
【2】DEARING N,JENNER A G.Magnetic and magnetoelastic properties of melt-spun Ni-Mn-Ga[J].IEEE Trans Magn,2006,42:78-80.
【3】CHERNENKO V A,PONS J,CESARI E,et al.Transformation behaviour and martensite stabilization in the ferromagnetic Co-Ni-Ga Heusler alloy[J].Scripta Materialia,2004,50:225-229.
【4】FUJITA A,FUKAMICHI K,GEJIMA F,et al.Magnetic properties and large magnetic-field-induced strains in off-stoichiometric Ni-Mn-Al Heusler alloys[J].Applied Physics Letters,2000,77:3054-3056.
【5】OIKAWA K,OTA T,SUTOU Y,et al.Magnetic and martensitic phase transformations in a Ni54Ga27Fe19 alloy[J].Materials Transactions,2002,43:2360-2362.
【6】夏明六,马立群,阮爱杰,等.铁磁性形状记忆合金Ni50Ga27Fe17Co6的阻尼性能[J].机械工程材料,2009,33(3):50-52.
【7】徐祖耀.相变内耗与伪滞弹性[J].金属学报,2003,39(11):1121-1126.
【8】冯端,王业宁,丘第荣.金属物理[M].北京:科学出版社,1975:603-608.
相关信息