Preparation and Properties of Graphene/Lacquer Composite Antistatic Coating
摘 要
分别以碳系材料石墨烯、炭黑、石墨为导电填料,生漆复合物为基材制备生漆复合抗静电涂层,讨论了导电填料含量对涂层导电性与力学性能的影响,并用扫描电镜(SEM)和热重分析仪(TGA)对涂层进行分析。结果表明:当导电填料石墨烯、炭黑、石墨的添加量分别为0.6%、15%、15%时,涂层具备抗静电能力。石墨烯复合涂层的附着力为0级、柔韧性1 mm、耐冲击性50 cm,优于未加填料的涂层以及添加石墨、炭黑为导电填料的复合涂层。同时,石墨烯复合涂层的耐介质性能以及耐热性能均表现优异。
Abstract
Antistatic coatings based on raw lacquer and different fillers like graphene, carbon and graphite were prepared and characterized by SEM and TGA, and the effect of conductive fillers on conductivity and mechanical properties of the coating were investigated. The results suggested that the addition of 0.6% graphene, 15% carbon and 15% graphite could meet the requirement of antistatic coatings. The mechanical property test revealed that the properties of zerograde adhesion, 1 mm flexility and 50 cm impact resistance of graghene coating superior to those of the carbon coating, graphite coating and primitive coating. The investigation also showed that the graghene coating showed remarkable performance of corrosion-resistance and heat-resistance.
中图分类号 TG174.4 DOI 10.11973/fsyfh-201707011
所属栏目 试验研究
基金项目 湖南省科技计划项目(2014NK3065)
收稿日期 2016/1/6
修改稿日期
网络出版日期
作者单位点击查看
引用该论文: WAN Changxin,XIAO Shaobo,HUANG Qiongtao,KUANG Chuntao,YANG Yan,LIAO Youwei. Preparation and Properties of Graphene/Lacquer Composite Antistatic Coating[J]. Corrosion & Protection, 2017, 38(7): 533
共有人对该论文发表了看法,其中:
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】苏雅丽,彭毛来,杨名亮,等. 油罐导静电涂料研究进展[J]. 上海涂料,2013,51(11):31-34.
【2】夏中高,张浩. 水性导静电涂料的制备及性能研究[J]. 涂料工业,2015,45(3):58-63,68.
【3】黄坤,曾宪光,裴嵩峰,等. 石墨烯/环氧复合导电涂层的防腐性能研究[J]. 涂料工业,2015,45(1):17-20,43.
【4】杨保平,谭生,郭军红,等. 丙烯酸抗静电涂料的研制[J]. 塑料工业,2011,39(4):96-98.
【5】谢俊娜,郑龙辉,白卫斌,等. 紫外光固化法制备漆酚/铜复合导电涂料及其性能的研究[J]. 中国生漆,2012,31(3):4-6.
【6】石玉,张飞龙,魏朔南. 漆酚导静电防腐涂料的研究[J]. 西安工业学院学报,1999,19(2):58-62.
【7】张健,李萍. 二十世纪中国生漆科技发展概要[J]. 中国生漆,2000,19(2):4-11.
【8】LU L,YANG L,YANG Z,et al. Study on polymerized tung oil-natural lacquer modified coating and its properties[J]. Hubei Forestry Science & Technology,2014,43(4):96-106.
【9】WU T,TANG Y,WANG J,et al. Progress in graphene conductive polymer composites[J]. China Rubber/plastics Technology & Equipment,2014,40(2):1-10.
【10】石玉,孟祥飞,郑建龙. 导电涂料的研究现状及发展趋势[J]. 中国生漆,2008,27(2):35-38.
【11】LAI Q,LUO X. Study of the preparation of graphene conductive coating system[J]. Non-Metallic Mines,2014,43(3):28-29.
【12】AHARONI S M. Electrical resistivity of a composite of conducting particles in an insulating matrix[J]. Journal of Applied Physics,1972,43(5):2463-2465.
【13】RAO C N R,BISWAS K,SUBRAHMANYAM K S,et al. Graphene,the new nanocarbon[J]. J Mater Chem,2009,19(19):2457-2469.
【14】MEYER J,GEIM A,KATSNELSON M,et al. The structure of suspended graphene[C]//2007 APS March Meeting American Physical Society.[S.l.]:[s.n.],2007.
【2】夏中高,张浩. 水性导静电涂料的制备及性能研究[J]. 涂料工业,2015,45(3):58-63,68.
【3】黄坤,曾宪光,裴嵩峰,等. 石墨烯/环氧复合导电涂层的防腐性能研究[J]. 涂料工业,2015,45(1):17-20,43.
【4】杨保平,谭生,郭军红,等. 丙烯酸抗静电涂料的研制[J]. 塑料工业,2011,39(4):96-98.
【5】谢俊娜,郑龙辉,白卫斌,等. 紫外光固化法制备漆酚/铜复合导电涂料及其性能的研究[J]. 中国生漆,2012,31(3):4-6.
【6】石玉,张飞龙,魏朔南. 漆酚导静电防腐涂料的研究[J]. 西安工业学院学报,1999,19(2):58-62.
【7】张健,李萍. 二十世纪中国生漆科技发展概要[J]. 中国生漆,2000,19(2):4-11.
【8】LU L,YANG L,YANG Z,et al. Study on polymerized tung oil-natural lacquer modified coating and its properties[J]. Hubei Forestry Science & Technology,2014,43(4):96-106.
【9】WU T,TANG Y,WANG J,et al. Progress in graphene conductive polymer composites[J]. China Rubber/plastics Technology & Equipment,2014,40(2):1-10.
【10】石玉,孟祥飞,郑建龙. 导电涂料的研究现状及发展趋势[J]. 中国生漆,2008,27(2):35-38.
【11】LAI Q,LUO X. Study of the preparation of graphene conductive coating system[J]. Non-Metallic Mines,2014,43(3):28-29.
【12】AHARONI S M. Electrical resistivity of a composite of conducting particles in an insulating matrix[J]. Journal of Applied Physics,1972,43(5):2463-2465.
【13】RAO C N R,BISWAS K,SUBRAHMANYAM K S,et al. Graphene,the new nanocarbon[J]. J Mater Chem,2009,19(19):2457-2469.
【14】MEYER J,GEIM A,KATSNELSON M,et al. The structure of suspended graphene[C]//2007 APS March Meeting American Physical Society.[S.l.]:[s.n.],2007.
相关信息