Preparation and Properties of Ni-P-TiO2 Composite Coatings
摘 要
通过向Ni-P镀液中添加TiO2溶胶(2~11 mL/L)的方法在AZ31B镁合金表面制备了Ni-P-TiO2复合镀层。用电化学方法评价了复合镀层在3.5%(质量分数)NaCl溶液中的腐蚀行为;用扫描电镜(SEM)、透射电镜(TEM)和X射线衍射仪(XRD)分析了Ni-P-TiO2复合镀层的微观形貌和显微组织结构;用维氏硬度仪测试了Ni-P-TiO2复合镀层的显微硬度。结果表明:随着TiO2溶胶含量的增加,复合镀层组织中菜花状胞状颗粒的尺寸逐渐减小,硬度和耐蚀性均是先增大后减小;当TiO2含量为8 mL/L时,镀层的结构致密,且无明显缺陷和裂纹产生,其显微硬度和耐蚀性均达到最高;Ni-P-TiO2复合镀层有明显的点蚀电位,说明镀层在腐蚀介质中形成了钝化层,对镁合金起到更好的保护作用。
Abstract
Ni-P-TiO2 composite coatings were prepared on surface of AZ31B magnesium alloy by adding TiO2 sol (2-11 mL/L) to Ni-P bath. The corrosion behavior of the composite coating in 3.5% (mass fraction) NaCl solution was evaluated by electrochemical method. The micro morphology and microstructure of the composite coatings were characterized by scanning electron microscopy (SEM), transmission electron microscopy (TEM) and X-ray diffraction (XRD). The microhardness of the composite coatings was tested by Vickers hardness tester. The results show that the size of cauliflower-like particles in microstruture decreased with raising the TiO2 sol content, and the microhardness and corrosion resistance increased first and then decreased. When the TiO2 sol content was 8 mL/L, the composite coating had a compact structure without obvious defects and cracks, and its microhardness and corrosion resistance hit the best values. The Ni-P-TiO2 composite coatings had obvious pitting potential, indicating that the coating had formed a passivation layer in the corrosive medium, which provided a better protective effect for magnesium alloy.
中图分类号 TB304 DOI 10.11973/fsyfh-202008003
所属栏目 试验研究
基金项目
收稿日期 2019/1/19
修改稿日期
网络出版日期
作者单位点击查看
引用该论文: SONG Jiawen,WANG Ruihong. Preparation and Properties of Ni-P-TiO2 Composite Coatings[J]. Corrosion & Protection, 2020, 41(8): 11
共有人对该论文发表了看法,其中:
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】LI W,KANG Z X. Fabrication of corrosion resistant superhydrophobic surface with self-cleaning property on magnesium alloy and its mechanical stability[J]. Surface & Coatings Technology,2014,253(1):205-213.
【2】ZHANG J Y,KANG Z X. Effect of different liquid-solid contact models on the corrosion resistance of superhydrophobic magnesium surfaces[J]. Corrosion Science,2014,87(1):452-459.
【3】SONG G L,SHI Z M. Corrosion mechanism and evaluation of anodized magnesium alloys[J]. Corrosion Science,2014,85(1):126-140.
【4】LIU L J,SCHLEINGER M. Corrosion of magnesium and its alloys[J]. Corrosion Science,2009,51(8):1733-1737.
【5】李海燕,李志生,张世珍,等. 镁合金的腐蚀与防护进展[J]. 腐蚀与防护,2010,31(11):878-881.
【6】余祖孝,孙亚丽,黄新,等. pH值及温度对AZ31镁合金化学镀Ni-P合金性能的影响[J]. 热加工工艺,2017,46(4):193-196.
【7】温泉,马旭. 镀镍对镁合金AZ61耐腐蚀性能的影响[J]. 腐蚀与防护,2015,36(1):27-31.
【8】FARZANEH A,MOHAMMADI M,EHTESHAMZADEH M,et al. Electrochemical and structural properties of electroless Ni-P-SiC nanocomposite coatings[J]. Applied Surface Science,2013,276(1):697-704.
【9】ARAGHI A,PAYDAR M H. Electroless deposition of Ni-W-P-B4C nanocomposite coating on AZ91D magnesium alloy and investigation on its properties[J]. Vacuum,2013,89(1):67-70.
【10】KARTHIKEYAN S,RAMAMOORTHY B. Effect of reducing agent and nano Al2O3 particle on the properties of electroless Ni-P coating[J]. Applied Surface Science,2014,307(1):654-660.
【11】SZCZYGIEL B,TURKIEWICZ A,SERAFINCZUK J. Surface morphology and structure of Ni-P,Ni-P-ZrO2,Ni-W-P,Ni-W-P-ZrO2 coatings deposited by electroless method[J]. Surface & Coatings Technology,2008,202(9):1904-1910.
【12】ZHAO Q,LIU Y. Electroless Ni-Cu-P-PTFE composite coatings and their anticorrosion properties[J]. Surface & Coatings Technology,2005,200(7):2510-2514.
【13】WANG Y X,WANG S J,SHU X,et al. Preparation and property of sol-enhanced Ni-B-TiO2 nano-composite coatings[J]. Journal of Alloys Compounds,2014,617(1):472-478.
【14】KRISHNAVENI K,SANKARA T S N. Corrosion resistance of electrodeposited Ni-B and Ni-B-Si3N4 composite coatings[J]. Journal of Alloys Compounds,2009,480(2):765-770.
【15】KRISHNAVENI K,SANKARA T S N. Electrodeposited Ni-B coatings:formation and evaluation of hardness and wear resistance[J]. Materials Chemistry and Physics,2006,99(2/3):300-308.
【16】KRISHNAVENI K,SANKARA T S N. Wear resistance of electrodeposited Ni-B and Ni-B-Si3N4[J]. Journal of Alloys Compounds,2008,466(1/2):412-420.
【17】NOVAKOVI J,VASSILIOU P,SAMARA K,et al. Electroless Ni-P-TiO2 composite coatings:their production and properties[J]. Surface & Coatings Technology,2006,20(1):895-901.
【18】RANGANATHA S,VENKATESHA T V,VATHSALA K. Development of electroless Ni-Zn-P/nano-TiO2 composite coatings and their properties[J]. Applied Surface Science,2010,256(1):7377-7383.
【19】CHEN W W,GAO W,He Y D. A novel electroless plating of Ni-P-TiO2 nano-composite coatings[J]. Surface & Coatings Technology,2010,204(1):2493-2498.
【20】WANG Y X,TAY S L,WEI S H. Microstrure and properties of sol-enhanced Ni-Co-TiO2 nano-composite on mild steel[J]. Journal of Alloys Compounds,2015,649(1):222-228.
【21】KRISHNAVENI K,SANKARA T S N,SESHADRI S K. Wear resistance of electrodeposited Ni-B and Ni-B-Si3N4 composite coatings[J]. Journal of Materials Science,2008,44(1):433-440.
【2】ZHANG J Y,KANG Z X. Effect of different liquid-solid contact models on the corrosion resistance of superhydrophobic magnesium surfaces[J]. Corrosion Science,2014,87(1):452-459.
【3】SONG G L,SHI Z M. Corrosion mechanism and evaluation of anodized magnesium alloys[J]. Corrosion Science,2014,85(1):126-140.
【4】LIU L J,SCHLEINGER M. Corrosion of magnesium and its alloys[J]. Corrosion Science,2009,51(8):1733-1737.
【5】李海燕,李志生,张世珍,等. 镁合金的腐蚀与防护进展[J]. 腐蚀与防护,2010,31(11):878-881.
【6】余祖孝,孙亚丽,黄新,等. pH值及温度对AZ31镁合金化学镀Ni-P合金性能的影响[J]. 热加工工艺,2017,46(4):193-196.
【7】温泉,马旭. 镀镍对镁合金AZ61耐腐蚀性能的影响[J]. 腐蚀与防护,2015,36(1):27-31.
【8】FARZANEH A,MOHAMMADI M,EHTESHAMZADEH M,et al. Electrochemical and structural properties of electroless Ni-P-SiC nanocomposite coatings[J]. Applied Surface Science,2013,276(1):697-704.
【9】ARAGHI A,PAYDAR M H. Electroless deposition of Ni-W-P-B4C nanocomposite coating on AZ91D magnesium alloy and investigation on its properties[J]. Vacuum,2013,89(1):67-70.
【10】KARTHIKEYAN S,RAMAMOORTHY B. Effect of reducing agent and nano Al2O3 particle on the properties of electroless Ni-P coating[J]. Applied Surface Science,2014,307(1):654-660.
【11】SZCZYGIEL B,TURKIEWICZ A,SERAFINCZUK J. Surface morphology and structure of Ni-P,Ni-P-ZrO2,Ni-W-P,Ni-W-P-ZrO2 coatings deposited by electroless method[J]. Surface & Coatings Technology,2008,202(9):1904-1910.
【12】ZHAO Q,LIU Y. Electroless Ni-Cu-P-PTFE composite coatings and their anticorrosion properties[J]. Surface & Coatings Technology,2005,200(7):2510-2514.
【13】WANG Y X,WANG S J,SHU X,et al. Preparation and property of sol-enhanced Ni-B-TiO2 nano-composite coatings[J]. Journal of Alloys Compounds,2014,617(1):472-478.
【14】KRISHNAVENI K,SANKARA T S N. Corrosion resistance of electrodeposited Ni-B and Ni-B-Si3N4 composite coatings[J]. Journal of Alloys Compounds,2009,480(2):765-770.
【15】KRISHNAVENI K,SANKARA T S N. Electrodeposited Ni-B coatings:formation and evaluation of hardness and wear resistance[J]. Materials Chemistry and Physics,2006,99(2/3):300-308.
【16】KRISHNAVENI K,SANKARA T S N. Wear resistance of electrodeposited Ni-B and Ni-B-Si3N4[J]. Journal of Alloys Compounds,2008,466(1/2):412-420.
【17】NOVAKOVI J,VASSILIOU P,SAMARA K,et al. Electroless Ni-P-TiO2 composite coatings:their production and properties[J]. Surface & Coatings Technology,2006,20(1):895-901.
【18】RANGANATHA S,VENKATESHA T V,VATHSALA K. Development of electroless Ni-Zn-P/nano-TiO2 composite coatings and their properties[J]. Applied Surface Science,2010,256(1):7377-7383.
【19】CHEN W W,GAO W,He Y D. A novel electroless plating of Ni-P-TiO2 nano-composite coatings[J]. Surface & Coatings Technology,2010,204(1):2493-2498.
【20】WANG Y X,TAY S L,WEI S H. Microstrure and properties of sol-enhanced Ni-Co-TiO2 nano-composite on mild steel[J]. Journal of Alloys Compounds,2015,649(1):222-228.
【21】KRISHNAVENI K,SANKARA T S N,SESHADRI S K. Wear resistance of electrodeposited Ni-B and Ni-B-Si3N4 composite coatings[J]. Journal of Materials Science,2008,44(1):433-440.
相关信息