Corrosion Failure Causes of Surface Oil Pipe in an Overseas High-sulfur and High-salt Oilfield
摘 要
对服役于高硫高盐原油中的失效管段的化学成分和显微组织进行分析,对产出水进行微生物检测,采用扫描电子显微镜(SEM)、能谱仪(EDS)及X射线衍射(XRD)等手段对腐蚀产物进行分析。结果表明:微生物腐蚀(MIC)是导致管道发生腐蚀泄漏的主要原因。油田产量低于预期造成管内原油低流速、含水率高于预期,以及停产后未及时清管造成游离水析出并沉积在管道底部,这些都为硫酸盐还原菌(SRB)等细菌的滋生繁殖创造了有利条件,从而导致管道的腐蚀失效。介质中的H2S、CO2以及Cl-共同参与了腐蚀过程。
Abstract
Corrosion failure of oil pipelines in a high-sulfur and high-salt oilfield was analyzed by means of chemical composition and microstructure analyses, microbiological detection of produced water, as well as corrosion morphology observation and corrosion product analysis using SEM, EDS, XRD etc. The results show that microbiological-induced corrosion (MIC) was the main reason of corrosion leakage of the pipeline. The oil production lower than expection resulted in low flow rate of the crude oil in the pipeline, the water cut was higher than expection. And the pipeline was not cleaned in time after the production, causing free water to precipitate at the bottom of pipeline. All of these created favorable conditions for the breeding and reproduction of sulfate reducing bacteria (SRB) and thus led to corrosion failure of the pipeline. H2S, CO2 and Cl- in the corrosive medium jointly participated in the corrosion process.
中图分类号 TG174 DOI 10.11973/fsyfh-202103012
所属栏目 失效分析
基金项目
收稿日期 2019/1/11
修改稿日期
网络出版日期
作者单位点击查看
引用该论文: CHEN Lijuan,YU Yong,ZHANG Hong,FAN Xuehua,GU Feng,JI Yongbo. Corrosion Failure Causes of Surface Oil Pipe in an Overseas High-sulfur and High-salt Oilfield[J]. Corrosion & Protection, 2021, 42(3): 73
共有人对该论文发表了看法,其中:
人认为该论文很差
人认为该论文较差
人认为该论文一般
人认为该论文较好
人认为该论文很好
参考文献
【1】尹宝俊,赵文轸,史交齐. 金属微生物腐蚀的研究[J]. 四川化工,2004,7(1):30-33.
【2】刘宏伟,徐大可,吴亚楠,等. 微生物生物膜下的钢铁材料腐蚀研究进展[J]. 腐蚀科学与防护技术,2015,27(5):409-418.
【3】熊福平,王军磊,FADHIL A A,等. 硫酸盐还原菌诱导应力腐蚀开裂研究进展[J]. 腐蚀科学与防护技术,2018,30(3):213-221.
【4】向龙斌,张吉昌,刘心蕊,等. 微生物腐蚀与采出水的微生物防腐蚀——回顾与应用实例[J]. 腐蚀科学与防护技术,2019,31(1):85-91.
【5】管方,翟晓凡,段继周,等. 阴极极化对硫酸盐还原菌腐蚀影响的研究进展[J]. 中国腐蚀与防护学报,2018,38(1):1-9.
【6】VORN WOLZOGEN KUKR C A,VAN VLUGT L S,GRAFI-TRRRING D,et al. Elactrobiochemich process manscrobe gronden water[J]. Corrosion.1984,18(6):147-156.
【7】李家俊,刘玉民,张香文,等. 油田回注水中硫酸盐还原菌对金属腐蚀的机理及其防治方法[J]. 工业水处理,2007,27(11):4-7.
【8】羊东明,石鑫,李亚光. 塔河12区高含H2S和CO2伴生气管道防腐蚀技术[J]. 腐蚀与防护,2013,34(6):545-548.
【9】赵章明. 油气井腐蚀防护与材质选择指南[M]. 北京:石油工业出版社,2011.
【10】杨建炜,张雷,路民旭. 油气田CO2/H2S共存条件下的腐蚀研究进展与选材原则[J]. 腐蚀科学与防护技术,2009,21(4):401-405.
【11】FIERRO G,INGO G M,MANCIA F. XPS investigation on the corrosion behavior of 13Cr martensitic stainless steel in CO2-H2S-Cl- environments[J]. Corrosion,1989,45(10):814-823.
【2】刘宏伟,徐大可,吴亚楠,等. 微生物生物膜下的钢铁材料腐蚀研究进展[J]. 腐蚀科学与防护技术,2015,27(5):409-418.
【3】熊福平,王军磊,FADHIL A A,等. 硫酸盐还原菌诱导应力腐蚀开裂研究进展[J]. 腐蚀科学与防护技术,2018,30(3):213-221.
【4】向龙斌,张吉昌,刘心蕊,等. 微生物腐蚀与采出水的微生物防腐蚀——回顾与应用实例[J]. 腐蚀科学与防护技术,2019,31(1):85-91.
【5】管方,翟晓凡,段继周,等. 阴极极化对硫酸盐还原菌腐蚀影响的研究进展[J]. 中国腐蚀与防护学报,2018,38(1):1-9.
【6】VORN WOLZOGEN KUKR C A,VAN VLUGT L S,GRAFI-TRRRING D,et al. Elactrobiochemich process manscrobe gronden water[J]. Corrosion.1984,18(6):147-156.
【7】李家俊,刘玉民,张香文,等. 油田回注水中硫酸盐还原菌对金属腐蚀的机理及其防治方法[J]. 工业水处理,2007,27(11):4-7.
【8】羊东明,石鑫,李亚光. 塔河12区高含H2S和CO2伴生气管道防腐蚀技术[J]. 腐蚀与防护,2013,34(6):545-548.
【9】赵章明. 油气井腐蚀防护与材质选择指南[M]. 北京:石油工业出版社,2011.
【10】杨建炜,张雷,路民旭. 油气田CO2/H2S共存条件下的腐蚀研究进展与选材原则[J]. 腐蚀科学与防护技术,2009,21(4):401-405.
【11】FIERRO G,INGO G M,MANCIA F. XPS investigation on the corrosion behavior of 13Cr martensitic stainless steel in CO2-H2S-Cl- environments[J]. Corrosion,1989,45(10):814-823.
相关信息