Page 89 - 电力与能源2023年第五期
P. 89

第 44 卷 第 5 期                          电力与能源
                   2023 年 10 月                                                                          511

                                                                                       DOI:10.11973/dlyny202305016
                  发电技术


                             使用凝汽器清洁因子在线监视并优化


                                              循环水运行的研究



                                                    周顺利 ,金           浩  2
                                                             1
                              (1. 国能徐州发电有限公司,安徽 徐州 221166;2. 田集发电厂,安徽 淮南 232098)

                    摘   要:分析了电厂循环水冷却水系统常见的结垢、沉积问题及其对凝汽器运行效率带来的影响,介绍了使用
                    动态清洁因子表征凝汽器表面结垢情况的方法,并使用此方法分析了电厂凝汽器运行案例。实践表明:此方
                    法可以有效排除发电负荷、背压变化、循环水温度等干扰因素,快速发现凝汽器的结垢趋势并作出提前响应。
                    关键词:凝汽器;清洁因子;循环水处理
                    作者简介:周顺利(1975—),男,高级工程师,从事电厂化学及环保专业技术管理工作。
                    中图分类号:TM611.31    文献标志码:A    文章编号:2095-1256(2023)05-0511-03
                  Application of Condenser Cleaning Factor in Online Monitoring and Optimization of
                                               Circulating Water Operation



                                                               1
                                                   ZHOU Shunli ,JIN Hao  2

                          (1. State Energy Xuzhou Power Generation Co.,Ltd.,Xuzhou 221166,Anhui Province,China;




                                      2. Tianji Power Plant,Huainan 232098,Anhui Province,China)




                    Abstract:This paper analyzes the common scaling and deposition problems in the circulating water cooling water
                    system of power plant and the influence on the condenser operation efficiency, introduces the method of using dy⁃
                    namic cleaning factor to characterize the scale on the surface of the condenser, and analyzes the operation case of
                    the condenser by using this method. The practice shows that this method can effectively eliminate the interference
                    factors such as power generation load, back pressure change, circulating water temperature, and quickly find the
                    trend of condenser scaling and respond in advance.


                    Key words:condenser,cleaning factor,circulating water treatment

                    凝汽器是电站凝汽式汽轮机发电机组的重                           精力甚至停机来处理换热管的结垢问题                 [1-3] 。
                要辅助设备之一。凝汽器的高效运行是发电机
                                                                 1 循环水常见问题及对凝汽器的影响
                组高效运行的保障。根据行业经验,真空度每提
                高 1 kPa,供电煤耗可以下降 2. 6 g,kWh (负荷                      以江苏某电厂 2 台 1 000 MW 机组的循环水
                                                     -1
                                                                                                       3
                超过 80%,额定真空度附近)。                                 系统为例,每套循环水系统保有水量 7 万 m ,循环
                                                                         3
                                                                            -1
                    随着环保法规的趋严和节水意识的增强,电                          量 10 万 m·h ,设计温差 12 ℃。补水来源为运河
                厂循环冷却水系统大都在高浓缩倍数下运行,循                            水,水质指标如表 1 所示。
                环水的碱度、硬度都处在较高的水平。这给循环                                   表 1 江苏某电厂补水水质主要指标
                水的阻垢控制带来巨大的挑战。据统计,凝汽器                                             总硬度
                                                                        电导率/               总碱度/      悬浮物/
                                                                 pH 值           (1/2Ca)/
                长期运行后换热管内侧结垢是电厂普遍存在的问                                 (μS·cm )           (mmol·L ) (mg·L )
                                                                                                -1
                                                                            -1
                                                                                                         -1
                                                                               (mmol·L )
                                                                                      -1
                题,结垢会导致端差上升,凝汽器换热效率下降,                           8. 58   1 376     8. 02     3. 9     21. 20
                机组经济性下降,因此电厂不得不定期投入大量
   84   85   86   87   88   89   90   91   92   93   94